酸性红染料脱色研究

文档编号:HG050  文档字数:10349,页数:26  附任务书

摘要: 二氧化氯具有强氧化性、不稳定性和消毒性，其氧化能力是次氯酸的9倍多，是氯的2.6倍。本文在生产和制备二氧化氯及稳定性二氧化氯的基础上，用分光光度法测定反应后酸性红染料的含量，从而计算二氧化氯对酸性红染料的脱色率。研究反应温度、pH值、搅拌速度、二氧化氯用量、酸性红染料起始浓度、反应时间对酸性红染料的脱色效果。实验结果表明：二氧化氯对酸性红染料的脱色率在一定条件下能达到95%以上，反应温度、搅拌速度、酸性红染料起始浓度对脱色率影响不大，反应时间也很快，5分钟基本上完全反应，在酸性条件下对脱色率没什么影响，但在碱性条件下pH值越大脱色率越低。二氧化氯对酸性红染料脱色的较佳条件：反应温度25℃,反应时间10min，转速250r/min，pH=6，酸性红染料与二氧化氯反应的摩尔比为1：3。
 
 
 关键词：  二氧化氯； 酸性红染料； 脱色率； 分光光度法
 
 

Study on the Decolorization of Acid Red
 
Abstract: Chlorine dioxide has strong property of oxidation, the instability and the disinfection, its oxidized ability is more than 9 time of hypochlorous, and is 2.6 times of chlorine.  This article is based on the production and the preparation of chlorine dioxide and stable chlorine dioxide, the content of the acid red was after reaction determined by Spectrophotometric methods, thus decolorization rate of acid red was calculated with chlorine dioxide. Then the decolorization effect of the acid red by reaction temperature, pH, mixing speed, the amount of chlorine dioxide, concentration of acid red, reaction time were studied. The experimental result indicated that, the decolorization rate can achieve above 95% by chlorine dioxide under the certain condition. The reaction temperature, the mixing speed, and concentration of the acid red have no evident influence to the decolorization rate. The reaction is very quick. The reaction would be completed within 5 minutes, so it has no influence to decolorization rate under acidic condition, but under the alkalinity condition, the larger pH is , the lower decolorization rate is. So the best condition were the followings: reaction temperature is 25℃, reaction time is 10min, rotational speed is 250r/min, pH is 6, the ratio of the acid red and a chlorine dioxide is 1: 3.

 
 Keywords:  Chlorine dioxide;  Acid red;  Decolorization rate;   Spectrometric

 
 
目  录
1  绪论 7
 1.1 二氧化氯的性质 7
 1.2 印染废水处理的方法 7
 1.3 二氧化氯的脱色机理 8
 1.4 二氧化氯的制备方法 8
 1.5 应用概况 9
 1.6 二氧化氯在印染废水处理中的应用 9
2  实验部分 11
 2.1 实验试剂与玻璃仪器 12
 2.2 实验步骤 12
3  实验结果与讨论 14
 3.1 标准曲线的绘制 14
 3.2 单因素考察 16
 3.3 脱色率与时间的关系拟合 23
 3.4 染料与二氧化氯反应的摩尔比推算 24
4 总结与展望 25
致 谢 27
参考文献 28

相关论文